AD 2017-19-08 SUPERSEDED

We are adopting a new airworthiness directive (AD) for all Airbus Defense and Space S.A. Model C-212-CB, C-212-CC, C-212-CD, C- 212-CE, and C-212-DF airplanes. This AD was prompted by reports of failures of the rudder pedal control system support. This AD requires modifying the rudder pedal adjustment system. We are issuing this AD to address the unsafe condition on these products.

Final rule.

Adoption of the Amendment \n\n\n\tAccordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows: \n\nPART 39--AIRWORTHINESS DIRECTIVES \n\n0 1. The authority citation for part 39 continues to read as follows: \n\n\n\tAuthority: 49 U.S.C. 106(g), 40113, 44701. \n\n\n\nSec. 39.13 (Amended) \n\n0 2. The FAA amends Sec. 39.13 by adding the following new airworthiness directive (AD): \n\n2017-19-08 Airbus Defense and Space S.A. (Formerly Known as Construcciones Aeronauticas, S.A.): Amendment 39-19038; Docket No. FAA-2017-0623; Product Identifier 2017-NM-024-AD. \n\n(a) Effective Date \n\n\n\tThis AD is effective October 25, 2017. \n\n(b) Affected ADs \n\n\n\tNone. \n\n(c) Applicability \n\n\n\tThis AD applies to all Airbus Defense and Space S.A. Model C- 212-CB, C-212-CC, C-212-CD, C-212-CE, and C-212-DF airplanes, certificated in any category. \n\n(d) Subject \n\n\n\tAir Transport Association (ATA) of America Code 27, Flight controls. \n\n(e)Reason \n\n\n\tThis AD was prompted by reports of failures of the rudder pedal control system support and a determination that the welding area of the affected support structure had broken. We are issuing this AD to prevent failure of the rudder control system, which could result in reduced controllability of the airplane. \n\n(f) Compliance \n\n\n\tComply with this AD within the compliance times specified, unless already done. \n\n(g) Modification \n\n\n\tWithin 12 months after the effective date of this AD: Modify the rudder pedal adjustment system, in accordance with the Accomplishment Instructions of EADS CASA Service Bulletin SB-212-27- 0057, dated May 21, 2014. \n\n(h) Other FAA AD Provisions \n\n\n\tThe following provisions also apply to this AD: \n\t(1) Alternative Methods of Compliance (AMOCs): The Manager, International Section, Transport Standards Branch, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the International Section, send it to the attention of the person identified in paragraph (i)(2) of this AD. Information may be emailed to: 9-ANM-116-AMOC-REQUESTS@faa.gov. Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office. \n\t(2) Contacting the Manufacturer: For any requirement in this AD to obtain corrective actions from a manufacturer, the action must be accomplished using a method approved by the Manager, International Section, Transport Standards Branch, FAA; or the European Aviation Safety Agency (EASA); or EADS CASA's EASA Design Organization Approval (DOA). If approved by the DOA, the approval must include the DOA-authorized signature. \n\n(i) Related Information(1) Refer to Mandatory Continuing Airworthiness Information (MCAI) EASA Airworthiness Directive 2017-0036, dated February 21, 2017, for related information. This MCAI may be found in the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2017-0623. \n\t(2) For more information about this AD, contact Shahram Daneshmandi, Aerospace Engineer, International Section, Transport Standards Branch, FAA, 1601 Lind Avenue SW., Renton, WA 98057-3356; telephone 425-227-1112; fax 425-227-1149. \n\n(j) Material Incorporated by Reference \n\n\n\t(1) The Director of the Federal Register approved the incorporation by reference (IBR) of the service information listed in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51. \n\t(2) You must use this service information as applicable to do the actions required by this AD, unless this AD specifies otherwise. \n\t(i) EADS CASA Service Bulletin SB-212-27-0057, dated May 21, 2014. \n\t(ii) Reserved. \n\t(3) For service information identified in this AD, contact Airbus Defense and Space Services/Engineering Support, Avenida de Arag(oacute)n 404, 28022 Madrid, Spain; telephone +34 91 585 55 84; fax +34 91 585 31 27; email MTA.TechnicalService@airbus.com. \n\t(4) You may view this service information at the FAA, Transport Standards Branch, 1601 Lind Avenue SW., Renton, WA. For information on the availability of this material at the FAA, call 425-227-1221. \n\t(5) You may view this service information that is incorporated by reference at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, call 202-741-6030, or go to: http://www.archives.gov/federal-register/cfr/ibr-locations.html.

Discussion \n\n\n\tWe issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 by adding an AD that would apply to all Airbus Defense and Space S.A. Model C-212-CB, C-212-CC, C-212-CD, C-212-CE, and C-212-DF airplanes. The NPRM published in the Federal Register on June 27, 2017 (82 FR 29019) (''the NPRM''). \n\tThe European Aviation Safety Agency (EASA), which is the Technical Agent for the Member States of the European Union, has issued EASA Airworthiness Directive 2017-0036, dated February 21, 2017 (referred to after this as the Mandatory Continuing Airworthiness Information, or ''the MCAI''), to correct an unsafe condition for all Airbus Defense and Space S.A. Model C-212-CB, C-212-CC, C-212-CD, C-212-CE, and C-212- DF airplanes. The MCAI states: \n\n\n\tFailures were reported of the pedal control system support of CASA C-212 aeroplanes. Subsequent investigation revealed that the welding area of the affected support structure had broken. \n\tThis condition, if not corrected, could lead to failure of the rudder control system, possibly resulting in reduced control of the aeroplane. \n\tTo address this potential unsafe condition, EADS-CASA issued Service Bulletin (SB) SB-212-27-0057 to provide modification instructions. \n\tFor the reasons described above, this (EASA) AD requires modification of the rudder pedal adjustment system. \n\n\n\tYou may examine the MCAI in the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2017- 0623. \n\nComments \n\n\n\tWe gave the public the opportunity to participate in developing this AD. We received no comments on the NPRM or on the determination of the cost to the public. \n\nConclusion \n\n\n\tWe reviewed the relevant data and determined that air safety and the public interest require adopting this AD as proposed except for minor editorial changes. We have determined that these minor changes: \n\tAre consistent with the intent that was proposedin the NPRM for correcting the unsafe condition; and \n\tDo not add any additional burden upon the public than was already proposed in the NPRM. \n\nRelated Service Information Under 1 CFR Part 51 \n\n\n\tAirbus Defense and Space S.A. has issued EADS CASA Service Bulletin SB-212-27-0057, dated May 21, 2014. This service information describes procedures for modifying the rudder pedal adjustment system. This service information is reasonably available because the interested parties have access to it through their normal course of business or by the means identified in the ADDRESSES section. \n\nCosts of Compliance \n\n\n\tWe estimate that this AD affects 42 airplanes of U.S. registry. \n\tWe estimate the following costs to comply with this AD: \n\n\n\tEstimated Costs ---------------------------------------------------------------------------------------------------------------- \n\tCost per Cost on U.S. \n\tAction Labor cost Parts cost productoperators ---------------------------------------------------------------------------------------------------------------- Modification........................ 9 work-hours x $85 per $5,683 $6,448 $270,816 \n\thour = $765. ---------------------------------------------------------------------------------------------------------------- \n\nAuthority for This Rulemaking \n\n\n\tTitle 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. ''Subtitle VII: Aviation Programs,'' describes in more detail the scope of the Agency's authority. \n\n((Page 43836)) \n\n\n\tWe are issuing this rulemaking under the authority described in ''Subtitle VII, Part A, Subpart III, Section 44701: General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action. \n\tThis AD is issued in accordance with authority delegated by the Executive Director, Aircraft Certification Service, as authorized by FAA Order 8000.51C. In accordance with that order, issuance of ADs is normally a function of the Compliance and Airworthiness Division, but during this transition period, the Executive Director has delegated the authority to issue ADs applicable to transport category airplanes to the Director of the System Oversight Division. \n\nRegulatory Findings \n\n\n\tWe determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government. \n\tFor the reasons discussed above, I certify that this AD: \n\t1. Is not a ''significant regulatory action'' under Executive Order 12866; \n\t2. Is not a ''significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); \n\t3. Will not affect intrastate aviation in Alaska; and \n\t4. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. \n\nList of Subjects in 14 CFR Part 39 \n\n\n\tAir transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.

The Director of the Federal Register approved the incorporation by reference of a certain publication listed in this AD as of October 25, 2017. \nADDRESSES: For service information identified in this final rule, contact Airbus Defense and Space Services/Engineering Support, Avenida de Arag(oacute)n 404, 28022 Madrid, Spain; telephone +34 91 585 55 84; fax +34 91 585 31 27; email MTA.TechnicalService@airbus.com. You may view this referenced service information at the FAA, Transport Standards Branch, 1601 Lind Avenue SW., Renton, WA. For information on the availability of this material at the FAA, call 425-227-1221. It is also available on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2017-0623. \n\nExamining the AD Docket \n\n\n\tYou may examine the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2017- 0623; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Office (telephone 800-647-5527) is Docket Management Facility, U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue SE., Washington, DC 20590.

Shahram Daneshmandi, Aerospace Engineer, International Section, Transport Standards Branch, FAA, 1601 Lind Avenue SW., Renton, WA 98057-3356; telephone 425-227-1112; fax 425-227-1149.