AD 2010-15-09 ACTIVE

We are adopting a new airworthiness directive (AD) for the products listed above that will supersede an existing AD. This AD results from mandatory continuing airworthiness information (MCAI) issued by the aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as: \n\n\tIt has been found the possibility of heating deactivation of Air Data System (ADS) sensors due to its inadequate automatic logic, when ADS/AOA knob is on AUTO position associated with the following messages: \n\n--DC BUS 1 OFF displayed on Crew Alerting System\n--CAS in conjunction with STBY HTR FAIL (which means loss of power on DC BUS 1); or \n--EMER BUS OFF displayed on CAS (which means loss of power on EMERGENCY BUS); or\n --ELEC EMERGENCY displayed on CAS (which means Electrical Emergency). \n\nThe loss of airplane air data sensors heating may cause ice buildup on their surfaces, which in turn may cause wrong pressureacquisitions resulting in erroneous flight parameters indication to the flight crew. Since this condition may occur in other airplanes of the same type and affects flight safety, an immediate corrective action is required. Thus, sufficient reason exists to request compliance with this AD in the indicated time limit. \n\nThis AD requires actions that are intended to address the unsafe condition described in the MCAI.

Final rule; request for comments.

2010-15-09 Empresa Brasileira de Aeronautica S.A. (EMBRAER): Amendment 39-16375; Docket No. FAA-2010-0733; Directorate Identifier 2010-CE-038-AD. \n\nEffective Date \n\n\t(a) This airworthiness directive (AD) becomes effective August 12, 2010. \n\nAffected ADs \n\n\t(b) This AD supersedes AD 2009-23-11; Amendment 39-16085. \n\nApplicability \n\n\t(c) This AD applies to the following Empresa Brasileira de Aeronautica S.A. (EMBRAER) Model EMB-500 airplanes, all serial numbers, certificated in any category: \n\t(i) Group 1 Airplanes (retains the actions and applicability from AD 2009-23-11): Airplanes for which service bulletin (SB) 500- 27-0003 has not been accomplished or that do not have an equivalent modification that was incorporated in the production line; and \n\t(ii) Group 2 Airplanes: Airplanes for which SB 500-27-0003 has been accomplished or have an equivalent modification that was incorporated in the production line. \n\nSubject \n\n\t(d) Air Transport Association of America (ATA)Code 30: Ice and Rain Protection. \n\nReason \n\n\t(e) The mandatory continuing airworthiness information (MCAI) states: \n\n\tIt has been found the possibility of heating deactivation of Air Data System (ADS) sensors due to its inadequate automatic logic, when ADS/AOA knob is on AUTO position associated with the following messages: \n\n--DC BUS 1 OFF displayed on Crew Alerting System\n--CAS in conjunction with STBY HTR FAIL (which means loss of power on DC BUS 1); or \n--EMER BUS OFF displayed on CAS (which means loss of power on EMERGENCY BUS); or \n--ELEC EMERGENCY displayed on CAS (which means Electrical Emergency). \n\nThe loss of airplane air data sensors heating may cause ice buildup on their surfaces, which in turn may cause wrong pressure acquisitions resulting in erroneous flight parameters indication to the flight crew. Since this condition may occur in other airplanes of the same type and affects flight safety, an immediate corrective action is required. Thus, sufficient reason exists to request compliance with this AD in the indicated time limit. \n\nThis AD action requires inserting information into the Abnormal Procedures section of the FAA-approved airplane flight manual (AFM). \n\nActions and Compliance \n\n\t(f) Group 1 Airplanes: unless already done, before further flight after December 2, 2009 (the effective date retained from AD 2009-23-11), incorporate into the AFM the following procedures section revisions. You may insert a copy of this AD into the appropriate sections of the AFM to comply with the requirements of this AD. \n\t(1) Revise the AFM by replacing the ELECTRICAL EMERGENCY procedures in AFM section 4-08, Abnormal Procedures, with Figure 1: \n\n\n\n\n\n\n\t(2) Revise the AFM by replacing the DC BUS 1 OFF procedure in AFM section 4-08, Abnormal Procedures, with Figure 2: \n\n\n\n\n\t(3) Revise the AFM by replacing the EMERGENCY BUS OFF procedure in AFM section 4-08, Abnormal Procedures, with Figure 3: \n\n\n\n\n\n\t(g) Group 2 Airplanes: Unless already done, before further flight after August 12, 2010 (the effective date of this AD), incorporate into the AFM the following procedures section revisions. You may insert a copy of this AD into the appropriate sections of the AFM to comply with the requirements of this AD. \n\t(1) Revise the AFM by replacing the ELECTRICAL EMERGENCY procedures in AFM section 4-08, Abnormal Procedures, with Figure 4: \n\n\n\n\n\n\n\n\t(2) Revise the AFM by replacing the DC BUS 1 OFF procedure in AFM section 4-08, Abnormal Procedures, with Figure 5: \n\n\n\n\n\t(3) Revise the AFM by replacing the EMERGENCY BUS OFF procedure in AFM section 4-08, Abnormal Procedures, with Figure 6: \n\n\n\n\nFAA AD Differences \n\n\tNote: This AD differs from the MCAI and/or service information as follows: No differences. \n\nOther FAA AD Provisions \n\n\t(h) The following provisions also apply to this AD: \n\t(1) Alternative Methods of Compliance (AMOCs): The Manager, Standards Office, FAA, has the authority to approveAMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. Send information to Attn.: Karl Schletzbaum, Aerospace Engineer, FAA, Small Airplane Directorate, 901 Locust, Room 301, Kansas City, Missouri 64106; telephone: (816) 329-4146; fax: (816) 329-4090. Before using any approved AMOC on any airplane to which the AMOC applies, notify your appropriate principal inspector (PI) in the FAA Flight Standards District Office (FSDO), or lacking a PI, your local FSDO. \n\t(2) Airworthy Product: For any requirement in this AD to obtain corrective actions from a manufacturer or other source, use these actions if they are FAA-approved. Corrective actions are considered FAA-approved if they are approved by the State of Design Authority (or their delegated agent). You are required to assure the product is airworthy before it is returned to service. \n\t(3) Reporting Requirements: For any reporting requirement in this AD, under the provisions of the Paperwork Reduction Act (44 U.S.C.3501 et.seq.), the Office of Management and Budget (OMB) has approved the information collection requirements and has assigned OMB Control Number 2120-0056. \n\nRelated Information \n\n\t(i) Refer to MCAI ANAC, AD No.: 2009-10-01R2, dated July 28, 2010, for related information.

Discussion \n\n\tOn November 2, 2009, we issued AD 2009-23-11, Amendment 39-16085 (74 FR 58195; November 12, 2009). That AD required actions intended to address an unsafe condition on the products listed above. \n\tSince we issued AD 2009-23-11, Empresa Brasileira de Aeronautica S.A. (EMBRAER) has issued service bulletin 500-27- 0003, dated May 18, 2010. The service bulletin changes flap position 3 from 36 degrees to 26 degrees. The service bulletin also changes flap position 3 Vref airspeeds and landing distance correction factors. Consequently, accomplishing the service bulletin necessitates changes to the Abnormal Procedures section of the FAA-approved airplane flight manual (AFM). The AFM changes were not included as part of the service bulletin. \n\tThe AGENCIA NACIONAL DE AVIACAO CIVIL--BRAZIL, which is the aviation authority for Brazil, has issued AD No.: 2009-10- 01R2, dated July 28, 2010 (referred to after this as "the MCAI''), to correct an unsafecondition for the specified products. The MCAI states: \n\n\tIt has been found the possibility of heating deactivation of Air Data System (ADS) sensors due to its inadequate automatic logic, when ADS/AOA knob is on AUTO position associated with the following messages: \n\n--DC BUS 1 OFF displayed on Crew Alerting System\n--CAS in conjunction with STBY HTR FAIL (which means loss of power on DC BUS 1); or \n--EMER BUS OFF displayed on CAS (which means loss of power on EMERGENCY BUS); or \n--ELEC EMERGENCY displayed on CAS (which means Electrical Emergency). \n\nThe loss of airplane air data sensors heating may cause ice buildup on their surfaces, which in turn may cause wrong pressure acquisitions resulting in erroneous flight parameters indication to the flight crew. Since this condition may occur in other airplanes of the same type and affects flight safety, an immediate corrective action is required. Thus, sufficient reason exists to request compliance with this AD in the indicated time limit. \n\nThis AD action requires inserting information into the Abnormal Procedures section of the FAA-approved AFM. You may obtain further information by examining the MCAI in the AD docket. \n\nFAA's Determination and Requirements of the AD \n\n\tThis product has been approved by the aviation authority of another country, and is approved for operation in the United States. Pursuant to our bilateral agreement with this State of Design Authority, they have notified us of the unsafe condition described in the MCAI and service information referenced above. We are issuing this AD because we evaluated all information provided by the State of Design Authority and determined the unsafe condition exists and is likely to exist or develop on other products of the same type design. \n\nDifferences Between This AD and the MCAI or Service Information \n\n\tWe have reviewed the MCAI and related service information and, in general, agree with their substance. But we might have found it necessary to use different words from those in the MCAI to ensure the AD is clear for U.S. operators and is enforceable. In making these changes, we do not intend to differ substantively from the information provided in the MCAI and related service information. \n\tWe might have also required different actions in this AD from those in the MCAI in order to follow FAA policies. Any such differences are described in a separate paragraph of the AD. These requirements take precedence over those copied from the MCAI. \n\nFAA's Determination of the Effective Date \n\n\tAn unsafe condition exists that requires the immediate adoption of this AD. The FAA has found that the risk to the flying public justifies waiving notice and comment prior to adoption of this rule because the loss of airplane air data sensors heating may cause ice buildup on their surface. This condition may cause wrong pressure acquisitions, resulting in erroneous flight parameters indication to the flight crew. Therefore, we determined that notice and opportunity for public comment before issuing this AD are impracticable and that good cause exists for making this amendment effective in fewer than 30 days. \n\nComments Invited \n\n\tThis AD is a final rule that involves requirements affecting flight safety, and we did not precede it by notice and opportunity for public comment. We invite you to send any written relevant data, views, or arguments about this AD. Send your comments to an address listed under the ADDRESSES section. Include "Docket No. FAA-2010-0733; Directorate Identifier 2010-CE-038-AD'' at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this AD. We will consider all comments received by the closing date and may amend this AD because of those comments. \n\tWe will post all comments we receive, without change, to http:// www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact we receive about this AD. \n\nAuthority for This Rulemaking \n\n\tTitle 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. "Subtitle VII: Aviation Programs,'' describes in more detail the scope of the Agency's authority. \n\tWe are issuing this rulemaking under the authority described in "Subtitle VII, Part A, Subpart III, Section 44701: General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action. \n\nRegulatory Findings \n\n\tWe determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government. \n\tFor the reasons discussed above, I certify that this AD: \n\t(1) Is not a "significant regulatory action'' under Executive Order 12866; \n\t(2) Is not a "significant rule'' under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and \n\t(3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. \n\tWe prepared a regulatory evaluation of the estimated costs to comply with this AD and placed it in the AD docket. \n\nList of Subjects in 14 CFR Part 39 \n\n\tAir transportation, Aircraft, Aviation safety, Safety. \n\nAdoption of the Amendment \n\nAccordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows: \n\nPART 39--AIRWORTHINESS DIRECTIVES \n\n1. The authority citation for part 39 continues to read as follows: \n\n\tAuthority: 49 U.S.C. 106(g), 40113, 44701. \n\nSec. 39.13 (Amended) \n\n2. The FAA amends Sec. 39.13 by removing Amendment 39-16085 (74 FR 58195; November 12, 2009), and adding the following new AD:

You may send comments by any of the following methods: \n\tFederal eRulemaking Portal: Go to http:// www.regulations.gov. Follow the instructions for submitting comments. \n\tFax: (202) 493-2251. \n\tMail: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590. \n\tHand Delivery: U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590, between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. \n\nExamining the AD Docket \n\n\tYou may examine the AD docket on the Internet at http:// www.regulations.gov; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Office (telephone (800) 647-5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.

Karl Schletzbaum, Aerospace Engineer, FAA, Small Airplane Directorate, 901 Locust, Room 301, Kansas City, Missouri 64106; telephone: (816) 329-4146; fax: (816) 329-4090.