AD 2011-03-09 ACTIVE

We are adopting a new airworthiness directive (AD) for the products listed above. This AD requires installing new fire handle shutoff system wiring. This AD was prompted by a possible latent failure in the fire handle shutoff relay circuit due to a lack of separation between engine wires. We are issuing this AD to minimize the possibility of a multiple engine shutdown due to single fire handle activation.

Final rule.

2011-03-09 The Boeing Company: Amendment 39-16593; Docket No. FAA- 2010-1043; Directorate Identifier 2010-NM-200-AD. \n\nEffective Date \n\n\n\t(a) This AD is effective March 14, 2011. \n\nAffected ADs \n\n\n\t(b) None. \n\nApplicability \n\n\n\t(c) This AD applies to all The Boeing Company Model MD-90-30 airplanes, certificated in any category. \n\nSubject \n\n\n\t(d) Joint Aircraft System Component (JASC)/Air Transport Association (ATA) of America Code 74, Ignition. \n\nUnsafe Condition \n\n\n\t(e) This AD was prompted by a possible latent failure in the fire handle shutoff relay circuit due to a lack of separation between engine wires. We are proposing this AD to minimize the possibility of a multiple engine shutdown due to single fire handle activation. \n\nCompliance \n\n\n\t(f) Comply with this AD within the compliance times specified, unless already done. \n\nWire Installation \n\n\n\t(g) Within 4,200 flight hours after the effective date of this AD, install new fire handle shutoffsystem wiring, in accordance with the Accomplishment Instructions of Boeing Alert Service Bulletin MD90-74A002, dated August 17, 2010. \n\nAlternative Methods of Compliance (AMOCs) \n\n\n\t(h)(1) The Manager, Los Angeles Aircraft Certification Office, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the manager of the ACO, send it to the attention of the person identified in the Related Information section of this AD. \n\t(2) Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office. \n\nRelated Information \n\n\n\t(i) For more information about this AD, contact William S. Bond, Aerospace Engineer, Propulsion Branch, ANM-140L, FAA, Los Angeles Aircraft Certification Office, 3960 Paramount Boulevard, Lakewood, CA 90712-4137; phone: 562-627-5253; fax: 562-627-5210; e-mail: William.Bond@faa.gov. \n\n\n\tMaterial Incorporated by Reference \n\n\n\t(j) You must use Boeing Alert Service Bulletin MD90-74A002, dated August 17, 2010, to do the actions required by this AD, unless the AD specifies otherwise. \n\t(1) The Director of the Federal Register approved the incorporation by reference of Boeing Alert Service Bulletin MD90- 74A002, dated August 17, 2010, under 5 U.S.C. 552(a) and 1 CFR part 51. \n\t(2) For service information identified in this AD, contact Boeing Commercial Airplanes, Attention: Data & Services Management, 3855 Lakewood Boulevard, MC D800-0019, Long Beach, California 90846- 0001; telephone 206-544-5000, extension 2; fax 206-766-5683; e-mail dse.boecom@boeing.com; Internet https://www.myboeingfleet.com. \n\t(3) You may review copies of the service information at the FAA, Transport AirplaneDirectorate, 1601 Lind Avenue, SW., Renton, Washington. For information on the availability of this material at the FAA, call 425-227-1221. \n\t(4) You may also review copies of the service information that is incorporated by reference at the National Archives and Records Administration (NARA). For information on the availability of this material at an NARA facility, call 202-741-6030, or go to http://www.archives.gov/federal_register/code_of_federal_regulations/ibr_locations.html.

Discussion \n\n\n\tWe issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to include an airworthiness directive (AD) that would apply to the specified products. That NPRM published in the Federal Register on November 5, 2010 (75 FR 68245). That NPRM proposed to require installing new fire handle shutoff system wiring. \n\nComments \n\n\n\tWe gave the public the opportunity to participate in developing this AD. We received no comments on the NPRM or on the determination of the cost to the public. \n\nExplanation of Change Made to the AD \n\n\n\tWe have revised this AD to identify the legal name of the manufacturer as published in the most recent type certificate data sheet for the affected airplane models. \n\nConclusion \n\n\n\tWe reviewed the relevant data and determined that air safety and the public interest require adopting the AD with the change described previously. We also determined that this change will not increase the economic burden on any operator or increase the scope of the AD. \n\nCosts of Compliance \n\n\n\tWe estimate that this AD will affect 25 airplanes of U.S. registry. \n\tWe estimate the following costs to comply with this AD: \n\n\n\tEstimated Costs ---------------------------------------------------------------------------------------------------------------- \n\tCost on U.S. \n\tAction Labor cost Parts cost Cost per product operators ---------------------------------------------------------------------------------------------------------------- Wiring change.................... 8 work-hours x $85 $489 $1,169 $29,225 \n\tper hour = $680. ---------------------------------------------------------------------------------------------------------------- \n\n\n\tAuthority for This Rulemaking \n\n\n\tTitle 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority. \n\tWe are issuing this rulemaking under the authority described in subtitle VII, part A, subpart III, section 44701: ''General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action. \n\nRegulatory Findings \n\n\n\tThis AD will not have federalism implications under Executive Order 13132. This AD will not have a \n\n((Page 6536)) \n\nsubstantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government. \n\tFor the reasons discussed above, I certify that this AD: \n\t(1) Is not a ''significant regulatory action'' under Executive Order 12866, \n\t(2) Is not a ''significant rule'' under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979), \n\t(3) Will not affect intrastate aviation in Alaska, and \n\t(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. \n\nList of Subjects in 14 CFR Part 39 \n\n\n\tAir transportation, Aircraft, Aviation safety, Incorporation by reference, Safety. \n\nAdoption of the Amendment \n\n\n\tAccordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows: \n\nPART 39--AIRWORTHINESS DIRECTIVES \n\n0 1. The authority citation for part 39 continues to read as follows: \n\n\n\tAuthority: 49 U.S.C. 106(g), 40113, 44701. \n\n\n\nSec. 39.13 (Amended)0 2. The FAA amends Sec. 39.13 by adding the following new airworthiness directive (AD):

For service information identified in this AD, contact Boeing Commercial Airplanes, Attention: Data & Services Management, 3855 Lakewood Boulevard, MC D800-0019, Long Beach, California 90846- 0001; telephone 206-544-5000, extension 2; fax 206-766-5683; e-mail dse.boecom@boeing.com; Internet https://www.myboeingfleet.com. You may review copies of the referenced service information at the FAA Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington. For information on the availability of this material at the FAA, call 425-227-1221. \n\nExamining the AD Docket \n\n\n\tYou may examine the AD docket on the Internet at http://www.regulations.gov; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this AD, the regulatory evaluation, any comments received, and other information. The address for the Docket Office (phone: 800-647-5527) is Document Management Facility, U.S. Department of Transportation, Docket Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New Jersey Avenue, SE., Washington, DC 20590.

William S. Bond, Aerospace Engineer, Propulsion Branch, ANM-140L, FAA, Los Angeles Aircraft Certification Office, 3960 Paramount Boulevard, Lakewood, CA 90712; phone: 562-627- 5253; fax: 562-627-5210; e-mail: William.Bond@faa.gov.