AD 2002-06-11

This amendment adopts a new airworthiness directive (AD), applicable to certain McDonnell Douglas Model MD-90-30 airplanes, that requires replacement of the existing strake feed-thru and internal electrical connectors with new, moisture-resistant connectors. This action is necessary to prevent moisture from entering the strake feed-thru and internal electrical connectors, which could lead to electrical arcing and a consequent fire in the electrical and electronic (E/E) compartment of the airplane. This action is intended to address the identified unsafe condition.

Final rule.

2002-06-11 McDonnell Douglas: Amendment 39-12689. Docket 2000-NM-195-AD. \n\n\tApplicability: Model MD-90-30 airplanes, certificated in any category; as listed in McDonnell Douglas Alert Service Bulletin MD90-30A017, Revision 02, dated September 26, 2000. \n\n\tNote 1: This AD applies to each airplane identified in the preceding applicability provision, regardless of whether it has been modified, altered, or repaired in the area subject to the requirements of this AD. For airplanes that have been modified, altered, or repaired so that the performance of the requirements of this AD is affected, the owner/operator must request approval for an alternative method of compliance in accordance with paragraph (b) of this AD. The request should include an assessment of the effect of the modification, alteration, or repair on the unsafe condition addressed by this AD; and, if the unsafe condition has not been eliminated, the request should include specific proposed actions to address it. \n\n\tCompliance: Required as indicated, unless accomplished previously. \n\n\tTo prevent moisture from entering the strake feed-thru and internal electrical connectors, which could lead to electrical arcing and a consequent fire in the electrical and electronic (E/E) compartment of the airplane, accomplish the following: \n\nReplacement \n\n\t(a) Within one year after the effective date of this AD: Replace the existing strake feed-thru and internal wire connectors with new connectors, in accordance with McDonnell Douglas Alert Service Bulletin MD90-30A017, Revision 02, dated September 26, 2000. \n\n\tNote 2: Replacements accomplished prior to the effective date of this AD in accordance with McDonnell Douglas Alert Service Bulletin MD90-30A017, Revision 01, dated April 3, 2000, or original issue, dated August 12, 1998, are considered acceptable for compliance with the applicable action specified in this AD. \n\nAlternative Methods of Compliance \n\n\t(b) An alternative method of compliance or adjustment of the compliance time that provides an acceptable level of safety may be used if approved by the Manager, Los Angeles Aircraft Certification Office (ACO), FAA. Operators shall submit their requests through an appropriate FAA Principal Maintenance Inspector, who may add comments and then send it to the Manager, Los Angeles ACO. \n\n\tNote 3: Information concerning the existence of approved alternative methods of compliance with this AD, if any, may be obtained from the Los Angeles ACO. \n\nSpecial Flight Permits \n\n\t(c) Special flight permits may be issued in accordance with sections 21.197 and 21.199 of the Federal Aviation Regulations (14 CFR 21.197 and 21.199) to operate the airplane to a location where the requirements of this AD can be accomplished. \n\nIncorporation by Reference \n\n\t(d) The actions shall be done in accordance with McDonnell Douglas Alert Service Bulletin MD90-30A017, Revision 02, dated September 26, 2000. This incorporation by reference was approved by the Director of the Federal Register in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Copies may be obtained from Boeing Commercial Aircraft Group, Long Beach Division, 3855 Lakewood Boulevard, Long Beach, California 90846, Attention: Data and Service Management, Dept. C1-L5A (D800-0024). Copies may be inspected at the FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; at the FAA, Los Angeles Aircraft Certification Office, 3960 Paramount Boulevard, Lakewood, California; or at the Office of the Federal Register, 800 North Capitol Street, NW., suite 700, Washington, DC. \n\nEffective Date \n\n\t(e) This amendment becomes effective on May 7, 2002.

A proposal to amend part 39 of the Federal Aviation Regulations (14 CFR part 39) to include an airworthiness directive (AD) that is applicable to certain McDonnell Douglas Model MD-90-30 airplanes was published in the Federal Register on January 4, 2002 (67 FR 537). That action proposed to require replacement of the existing strake feed-thru and internal electrical connectors with new, moisture-resistant connectors. \n\nComments \n\n\tInterested persons have been afforded an opportunity to participate in the making of this amendment. No comments were submitted in response to the proposal or the FAA's determination of the cost to the public. \n\nConclusion \n\n\tThe FAA has determined that air safety and the public interest require the adoption of the rule as proposed. \n\nCost Impact \n\n\tThere are approximately 99 McDonnell Douglas Model MD-90-30 airplanes of the affected design in the worldwide fleet. The FAA estimates that 25 airplanes of U.S. registry willbe affected by this AD, that it will take approximately 14 work hours per airplane to accomplish the required replacement, and that the average labor rate is $60 per work hour. Required parts are available at no charge from the manufacturer. Based on these figures, the cost impact of the requirements of this AD on U.S. operators is estimated to be $21,000, or $840 per airplane. \n\n\tThe cost impact figure discussed above is based on assumptions that no operator has yet accomplished any of the proposed requirements of this AD action, and that no operator would accomplish those actions in the future if this proposed AD were not adopted. However, the FAA has been advised that manufacturer warranty remedies are available for labor costs associated with accomplishing the actions required by this AD. Therefore, the future economic cost impact of this rule on U.S. operators may be less than the cost impact figure indicated above. The cost impact figures discussed in AD rulemaking actions represent only the time necessary to perform the specific actions actually required by the AD. These figures typically do not include incidental costs, such as the time required to gain access and close up, planning time, or time necessitated by other administrative actions. \n\nRegulatory Impact \n\n\tThe regulations adopted herein will not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government. Therefore, it is determined that this final rule does not have federalism implications under Executive Order 13132. \n\n\tFor the reasons discussed above, I certify that this action (1) Is not a "significant regulatory action" under Executive Order 12866; (2) is not a "significant rule" under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and (3) will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. A final evaluation has been prepared for this action and it is contained in the Rules Docket. A copy of it may be obtained from the Rules Docket at the location provided under the caption ADDRESSES. \n\nList of Subjects in 14 CFR Part 39 \n\n\tAir transportation, Aircraft, Aviation safety, Incorporation by reference, Safety. \n\nAdoption of the Amendment \n\n\tAccordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows: \n\nPART 39--AIRWORTHINESS DIRECTIVES \n\n\t1. The authority citation for part 39 continues to read as follows: \n\n\tAuthority: 49 U.S.C. 106(g), 40113, 44701. \n\nSec. 39.13 (Amended) \n\n\t2. Section 39.13 is amended by adding the following new airworthiness directive: