The Direction G n rale de l'Aviation Civile (DGAC), which is the airworthiness authority for France, recently notified the FAA that an unsafe condition may exist on certain Airbus Model A330 and A340 series airplanes. The DGAC advises that one operator has reported that, in response to a forward cargo compartment smoke warning, the cargo fire extinguishers were fired. Bottle #1 discharged extinguishing agent into the cargo compartment normally; however, bottle #2 did not discharge. Investigation revealed that debris from the cartridge/disc from bottle #1 had partially clogged the discharge pipe, which then prevented the extinguishing agent from being discharged from bottle #2. This condition, if not corrected, could result in an inadequate amount of fire extinguishing agent being discharged to the cargo compartment in the event of a fire.
Airbus has issued three service bulletin relevant to this problem:
1. Service Bulletin A330-26-3002, dated March 29, 1994, which is applicable to Model A330 series airplanes;
2. Service Bulletin A340-26-4007, Revision 1, dated May 16, 1994, which is applicable to Model A340 series airplanes; and
3. Service Bulletin A340-26-4007, Revision 2, dated November 22, 1994, which also is applicable to Model A340 series airplanes.
These service bulletins describe procedures for installing a modified discharge pipe between bottle #2 and the halon filter in the fire extinguishing system of the lower deck cargo compartment. The modified pipe entails two new hoses with an increased diameter and larger elbow radius, which will prevent the blockage problems caused by debris in the discharge pipe.
The DGAC classified these service bulletins as mandatory and issued French Airworthiness Directives (CN) 94-117-001(B), dated May 11, 1994, which is applicable to Model A330 series airplanes; and 94-118-007(B), dated May 11, 1994, which is applicable to Model A340 series airplanes; in order to assure thecontinued airworthiness of these airplanes in France.
These airplane models are manufactured in France and are type certificated for operation in the United States under the provisions of section 21.29 of the Federal Aviation Regulations (14 CFR 21.19) and the applicable bilateral airworthiness agreement. Pursuant to this bilateral airworthiness agreement, the DGAC has kept the FAA informed of the situation described above. The FAA has examined the findings of the DGAC, reviewed all available information, and determined that AD action is necessary for products of this type design that are certificated for operation in the United States.
Since an unsafe condition has been identified that is likely to exist or develop on other airplanes of the same type design registered in the United States, this AD is being issued to ensure that, in the event of a fire, adequate fire extinguishing agent is discharged into the cargo compartment. This AD requires replacing the fire extinguisher distribution pipe and attachments of the extinguishing system of the lower deck cargo compartment with a modified pipe assembly. The actions are required to be accomplished in accordance with the service bulletins described previously.
None of the Model A330 or A340 series airplanes affected by this action are on the U.S. Register. All airplanes included in the applicability of this rule currently are operated by non-U.S. operators under foreign registry; therefore, they are not directly affected by this AD action. However, the FAA considers that this rule is necessary to ensure that the unsafe condition is addressed in the event that any of these subject airplanes are imported and placed on the U.S. Register in the future.
Should an affected airplane be imported and placed on the U.S. Register in the future, it would require approximately 8 work hours to accomplish the required actions, at an average labor charge of $60 per work hour. Required parts would be provided free of charge by the manufacturer. Based on these figures, the total cost impact of this AD would be $480 per airplane.
Since this AD action does not affect any airplane that is currently on the U.S. register, it has no adverse economic impact and imposes no additional burden on any person. Therefore, notice and public procedures hereon are unnecessary and the amendment may be made effective in less than 30 days after publication in the Federal Register.
Comments Invited
Although this action is in the form of a final rule and was not preceded by notice and opportunity for public comment, comments are invited on this rule. Interested persons are invited to comment on this rule by submitting such written data, views, or arguments as they may desire. Communications shall identify the Rules Docket number and be submitted in triplicate to the address specified under the caption "ADDRESSES." All communications received on or before the closing date for comments will be considered, and this rule may be amended in light of the comments received. Factual information that supports the commenter's ideas and suggestions is extremely helpful in evaluating the effectiveness of the AD action and determining whether additional rulemaking action would be needed.
Comments are specifically invited on the overall regulatory, economic, environmental, and energy aspects of the rule that might suggest a need to modify the rule. All comments submitted will be available, both before and after the closing date for comments, in the Rules Docket for examination by interested persons. A report that summarizes each FAA-public contact concerned with the substance of this AD will be filed in the Rules Docket.
Commenters wishing the FAA to acknowledge receipt of their comments submitted in response to this rule must submit a self-addressed, stamped postcard on which the following statement is made: "Comments to Docket Number 95-NM-174-AD." The postcard will be date stamped and returned to the commenter.
The regulations adopted herein will not have substantial direct effects on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government. Therefore, in accordance with Executive Order 12612, it is determined that this final rule does not have sufficient federalism implications to warrant the preparation of a Federalism Assessment.
For the reasons discussed above, I certify that this action (1) is not a "significant regulatory action" under Executive Order 12866; (2) is not a "significant rule" under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and (3) will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. A final evaluation has been prepared for this action and it is contained in the Rules Docket. A copy of it may be obtained from the Rules Docket at the location provided under the caption "ADDRESSES."
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.
Adoption of the Amendment
Accordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows:
PART 39 - AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 USC 106(g), 40101, 40113, 44701.
39.13 - [Amended]
2. Section 39.13 is amended by adding the following new airworthiness directive: