AD 2021-14-09

The FAA is adopting a new airworthiness directive (AD) for certain Airbus Canada Limited Partnership Model BD-500-1A10 and BD-500- 1A11 airplanes. This AD was prompted by a design review that identified rib 0 of the center wing box (CWB) as an area where a single failure of a clamshell type refuel/defuel line coupling could lead to the accumulation of dangerous levels of electrostatic charges within the fuel tank. This AD requires replacing the clamshell type refuel/defuel line coupling in the CWB at rib 0 with a threaded type fuel coupling, and installing an additional support bracket and clamp in the CWB at rib 0, as specified in a Transport Canada Civil Aviation (TCCA) AD, which is incorporated by reference. The FAA is issuing this AD to address the unsafe condition on these products.

Final rule.

Adoption of the Amendment \n\n\n\tAccordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows: \n\nPART 39--AIRWORTHINESS DIRECTIVES \n\n0 1. The authority citation for part 39 continues to read as follows: \n\n\n\tAuthority: 49 U.S.C. 106(g), 40113, 44701. \n\n\n\nSec. 39.13 (Amended) \n\n0 2. The FAA amends Sec. 39.13 by adding the following new airworthiness directive: \n\n2021-14-09 Airbus Canada Limited Partnership (Type Certificate Previously Held by C Series Aircraft Limited Partnership (CSALP); Bombardier, Inc.): Amendment 39-21636; Docket No. FAA-2021-0339; Project Identifier MCAI-2020-01605-T. \n\n(a) Effective Date \n\n\n\tThis airworthiness directive (AD) is effective August 24, 2021. \n\n(b) Affected ADs \n\n\n\tNone. \n\n(c) Applicability \n\n\n\tThis AD applies to Airbus Canada Limited Partnership (type certificate previously held by C Series Aircraft Limited Partnership (CSALP); Bombardier, Inc.) Model BD-500-1A10 and BD-500-1A11 airplanes, certificated in any category, as identified in Transport Canada Civil Aviation (TCCA) AD CF-2020-04, dated March 9, 2020 (TCCA AD CF-2020-04). \n\n(d) Subject \n\n\n\tAir Transport Association (ATA) of America Code 28, Fuel. \n\n(e) Reason \n\n\n\tThis AD was prompted by a design review that identified rib 0 of the center wing box (CWB) as an area where a single failure of a clamshell type refuel/defuel line coupling could lead to the accumulation of dangerous levels of electrostatic charges within the fuel tank. The FAA is issuing this AD to address failure of a clamshell type refuel/defuel line coupling, which could lead to fuel tank ignition. \n\n(f) Compliance \n\n\n\tComply with this AD within the compliance times specified, unless already done. \n\n(g) Requirements \n\n\n\tExcept as specified in paragraph (h) of this AD: Comply with all required actions and compliance times specified in, and in accordance with, TCCA AD CF-2020-04. \n\n(h) Exceptions to TCCA AD CF-2020-04 \n\n\n\t(1) Where TCCA AD CF-2020-04 refers to its effective date, this AD requires using the effective date of this AD. \n\t(2) Where TCCA AD CF-2020-04 refers to hours air time, this AD requires using flight hours. \n\n(i) Other FAA AD Provisions \n\n\n\tThe following provisions also apply to this AD: \n\t(1) Alternative Methods of Compliance (AMOCs): The Manager, New York ACO Branch, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or responsible Flight Standards Office, as appropriate. If sending information directly to ATTN: Program Manager, Continuing Operational Safety, FAA, New York ACO Branch, 1600 Stewart Avenue, Suite 410, Westbury, NY 11590; telephone 516-228-7300; fax 516-794- 5531. Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the responsible FlightStandards Office. \n\t(2) Contacting the Manufacturer: For any requirement in this AD to obtain instructions from a manufacturer, the instructions must be accomplished using a method approved by the Manager, New York ACO Branch, FAA; or TCCA; or Airbus Canada's TCCA Design Approval Organization (DAO). If approved by the DAO, the approval must include the DAO-authorized signature. \n\n(j) Related Information \n\n\n\tFor more information about this AD, contact Joseph Catanzaro, Aerospace Engineer, Airframe and Propulsion Section, FAA, New York ACO Branch, 1600 Stewart Avenue, Suite 410, Westbury, NY 11590; telephone 516-228-7366; fax 516-794-5531; email 9-avs-nyaco-cos@faa.gov. \n\n(k) Material Incorporated by Reference \n\n\n\t(1) The Director of the Federal Register approved the incorporation by reference (IBR) of the service information listed in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51. \n\t(2) You must use this service information as applicable to do the actions required by this AD, unless this AD specifies otherwise. \n\t(i) Transport Canada Civil Aviation (TCCA) AD CF-2020-04, dated March 9, 2020. \n\t(ii) (Reserved) \n\t(3) For TCCA AD CF-2020-04, contact TCCA, Transport Canada National Aircraft Certification, 159 Cleopatra Drive, Nepean, Ontario K1A 0N5, Canada; telephone 888-663-3639; email AD-CN@tc.gc.ca; internet https://tc.canada.ca/en/aviation. \n\t(4) You may view this material at the FAA, Airworthiness Products Section, Operational Safety Branch, 2200 South 216th St., Des Moines, WA. For information on the availability of this material at the FAA, call 206-231-3195. This material may be found in the AD docket on the internet at https://www.regulations.gov by searching for and locating Docket No. FAA-2021-0339. \n\t(5) You may view this material that is incorporated by reference at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, email fedreg.legal@nara.gov, or go to: https://www.archives.gov/federal-register/cfr/ibr-locations.html. \n\n\n\tIssued on June 25, 2021. Lance T. Gant, Director, Compliance & Airworthiness Division, Aircraft Certification Service. (FR Doc. 2021-15351 Filed 7-19-21; 8:45 am) BILLING CODE 4910-13-P

Background \n\n\n\tThe TCCA, which is the aviation authority for Canada, has issued TCCA AD CF-2020-04, dated March 9, 2020 (TCCA AD CF-2020-04) (also referred to as the Mandatory Continuing Airworthiness Information, or the MCAI), to correct an unsafe condition for certain Airbus Canada Limited Partnership Model BD-500-1A10 and BD-500-1A11 airplanes. \n\tThe FAA issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 by adding an AD that would apply to certain Airbus Canada Limited Partnership Model BD-500-1A10 and BD-500-1A11 airplanes. The NPRM published in the Federal Register on April 26, 2021 (86 FR 21967). The NPRM was prompted by a design review that identified rib 0 of the CWB as an area where a single failure of a clamshell type refuel/defuel line coupling could potentially lead to the accumulation of dangerous levels of electrostatic charges within the fuel tank. The NPRM proposed to require replacing the clamshell type refuel/defuel line coupling in the CWB at rib 0 with a threaded type fuel coupling, and installing an additional support bracket and clamp in the CWB at rib 0, as specified in TCCA AD CF-2020-04. \n\tThe FAA is issuing this AD to address failure of a clamshell type refuel/defuel line coupling, which could lead to fuel tank ignition. See the MCAI for additional background information. \n\nComments \n\n\n\tThe FAA gave the public the opportunity to participate in developing this final rule. The FAA has considered the comment received. The Air Line Pilots Association, International (ALPA) stated its support for the NPRM. \n\nConclusion \n\n\n\tThe FAA reviewed the relevant data, considered the comment received, and determined that air safety and the public interest require adopting this final rule as proposed, except for minor editorial changes. The FAA has determined that these minor changes: \n\tAre consistent with the intent that was proposed in the NPRM for addressing the unsafe condition; and \n\tDonot add any additional burden upon the public than was already proposed in the NPRM. \n\nRelated Service Information Under 1 CFR Part 51 \n\n\n\tTCCA AD CF-2020-04 describes procedures for replacing the clamshell type refuel/defuel line coupling in the CWB at rib 0 with a threaded type fuel coupling, and installing an additional support bracket and clamp in the CWB at rib 0. This material is reasonably available because the interested parties have access to it through their normal course of business or by the means identified in the ADDRESSES section. \n\nCosts of Compliance \n\n\n\tThe FAA estimates that this AD affects 47 airplanes of U.S. registry. The FAA estimates the following costs to comply with this AD: \n\n\n\tEstimated Costs for Required Actions ---------------------------------------------------------------------------------------------------------------- \n\tCost per Cost on U.S. \n\tLabor cost Parts cost product operators ---------------------------------------------------------------------------------------------------------------- 27 work-hours x $85 per hour = $2,295........................ $7,191 $9,486 $445,842 ---------------------------------------------------------------------------------------------------------------- \n\n\n\n((Page 38213)) \n\nAuthority for This Rulemaking \n\n\n\tTitle 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs, describes in more detail the scope of the Agency's authority. \n\tThe FAA is issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701: General requirements. Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administratorfinds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action. \n\nRegulatory Findings \n\n\n\tThis AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government. \n\tFor the reasons discussed above, I certify that this AD: \n\t(1) Is not a ''significant regulatory action'' under Executive Order 12866, \n\t(2) Will not affect intrastate aviation in Alaska, and \n\t(3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. \n\nList of Subjects in 14 CFR Part 39 \n\n\n\tAir transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.