AD 2015-06-09

We are adopting a new airworthiness directive (AD) for Pacific Aerospace Limited (PAL) Model 750XL airplanes. This AD results from mandatory continuing airworthiness information (MCAI) issued by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as PAL Model 750XL airplanes manufactured with only one attitude indicator. A second attitude indicator is required for flights under instrument flight rules. We are issuing this AD to require actions to address the unsafe condition on these products.

Final rule.

Adoption of the Amendment

Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0 1. The authority citation for part 39 continues to read as follows:

Authority: 49 U.S.C. 106(g), 40113, 44701.

Sec. 39.13 [Amended]

0 2. The FAA amends Sec. 39.13 by adding the following new AD:

2015-06-09 Pacific Aerospace Limited: Amendment 39-18127; Docket No. FAA-2014-1002; Directorate Identifier 2014-CE-033-AD.

(a) Effective Date

This airworthiness directive (AD) becomes effective May 4, 2015.

(b) Affected ADs

None.

(c) Applicability

This AD applies to Pacific Aerospace Limited Model 750XL airplanes, all serial numbers, certificated in any category.

(d) Subject

Air Transport Association of America (ATA) Code 34: Navigation.

(e) Reason

This AD was prompted by mandatory continuing airworthiness information (MCAI) originated by an aviation authority of another country to identify and correct an unsafe condition on an aviation product. The MCAI describes the unsafe condition as Pacific Aerospace Limited Model 750XL airplanes manufactured with instrument panels with only one attitude indicator. A second attitude indicator is required to operate under instrument flight rules (IFR). A reversionary attitude indicator reduces the probability of a single point failure, which could result in loss of control. We are issuing this proposed AD to install a reversionary attitude indicator before operating in IFR conditions.

(f) Actions and Compliance

Unless already done, before the next flight requiring instrument flight rules (IFR) after the effective date of this AD, install a second attitude indicator into the right hand instrument panel or enable the reversionary mode on a Sandel SN3500 electronic horizontal situation indicator (EHSI), if installed, whichever is applicable, following the ACCOMPLISHMENT INSTRUCTIONS in Pacific Aerospace Limited Mandatory Service Bulletin PACSB/XL/074, Issue 2, dated November 4, 2014.

(g) Other FAA AD Provisions

The following provisions also apply to this AD:
(1) Alternative Methods of Compliance (AMOCs): The Manager, Standards Office, FAA, has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. Send information to ATTN: Karl Schletzbaum, Aerospace Engineer, 901 Locust, Room 301, Kansas City, Missouri 64106; telephone: (816) 329- 4123; fax: (816) 329-4090; email:

[[Page 16555]]

karl.schletzbaum@faa.gov. Before using any approved AMOC on any airplane to which the AMOC applies, notify your appropriate principal inspector (PI) in the FAA Flight Standards District Office (FSDO), or lacking a PI, your local FSDO.
(2) Airworthy Product: For any requirement in this AD to obtain corrective actions from a manufacturer or other source, use these actions if they are FAA-approved. Corrective actions are considered FAA-approved if they are approved by the State of Design Authority (or their delegated agent). You are required to assure the product is airworthy before it is returned to service.

(h) Related Information

Refer to MCAI in Civil Aviation Authority (CAA) AD DCA/750XL/ 17A, dated November 6, 2014, for related information. The MCAI can be found in the AD docket on the Internet at http://www.regulations.gov/#!documentDetail;D=FAA-2014-1002-0002.

(i) Material Incorporated by Reference

(1) The Director of the Federal Register approved the incorporation by reference (IBR) of the service information listed in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51.
(2) You must use this service information as applicable to do the actions required by this AD, unless the AD specifies otherwise.
(i) Pacific Aerospace Limited Mandatory Service Bulletin PACSB/ XL/074, Issue 2, dated November 4, 2014.
(ii) Reserved.
(3) For service information identified in this AD, contact Pacific Aerospace Limited, Airport Road, Private Bag 3027, Hamilton 3240, New Zealand; telephone: +64 7 843 6144; fax: +64 7 843 6134; email: pacific@aerospace.co.nz; Internet: http://www.aerospace.co.nz/.
(4) You may view this service information at the FAA, Small Airplane Directorate, 901 Locust, Kansas City, Missouri 64106. For information on the availability of this material at the FAA, call (816) 329-4148. In addition, you can access this service information on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2014-1002.
(5) You may view this service information that is incorporated by reference at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, call 202-741-6030, or go to: http://www.archives.gov/federal-register/cfr/ibr-locations.html.

Discussion

We issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to add an AD that would apply to Pacific Aerospace Limited Model 750XL airplanes. The NPRM was published in the Federal Register on December 8, 2014 (79 FR 72564). The NPRM proposed to correct an unsafe condition for the specified products and was based on mandatory continuing airworthiness information (MCAI) originated by an aviation authority of another country. The MCAI states:

This AD with effective date 10 November 2014 is prompted by a recent determination that certain PAL750XL aircraft were inadvertently manufactured with instrument panels with only one Attitude Indicator (AI). A second AI is required for PAL750XL operating under Instrument Flight Rules (IFR).

[[Page 16554]]

The AD mandates the installation of either a second AI, or the enablement of Reversionary Attitude mode in the Sandel Electronic Horizontal Situation Indicator (EHSI), if fitted, when operating under IFR.

The MCAI can be found in the AD docket on the Internet at: http://www.regulations.gov/#!documentDetail;D=FAA-2014-1002-0002.

Comments

We gave the public the opportunity to participate in developing this AD. We received no comments on the NPRM (79 FR 72564, December 8, 2014) or on the determination of the cost to the public.

Conclusion

We reviewed the relevant data and determined that air safety and the public interest require adopting the AD as proposed except for minor editorial changes. We have determined that these minor changes:
Are consistent with the intent that was proposed in the NPRM (79 FR 72564, December 8, 2014) for correcting the unsafe condition; and
Do not add any additional burden upon the public than was already proposed in the NPRM (79 FR 72564, December 8, 2014).

Relative Service Information Under 1 CFR part 51

We reviewed Pacific Aerospace Limited Mandatory Service Bulletin PACSB/XL/074,Issue 2, dated November 4, 2014. The service bulletin describes procedures for installing a second attitude indicator or enabling the reversionary mode on a Sandel SN3500 electronic horizontal situation indicator (EHSI), if installed, whichever is applicable. This service information is reasonably available; see ADDRESSES for ways to access this service information.

Costs of Compliance

We estimate that this AD will affect 17 products of U.S. registry. We also estimate that it would take about 6 work-hours per product to comply with the basic requirements of this AD. The average labor rate is $85 per work-hour. Required parts would cost about $3,500 per product.
Based on these figures, we estimate the cost of the AD on U.S. operators to be $68,170, or $4,010 per product.

Authority for This Rulemaking

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. ``Subtitle VII: Aviation Programs,'' describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in ``Subtitle VII, Part A, Subpart III, Section 44701: General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory Findings

We determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify this AD:
(1) Is not a ``significant regulatory action'' under Executive Order 12866,
(2) Is not a ``significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979),
(3) Will not affect intrastate aviation in Alaska, and
(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

Examining the AD Docket

You may examine the AD docket on the Internet at http://www.regulations.gov by searching for and locating Docket No. FAA-2014- 1002; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains the NPRM, the regulatory evaluation, any comments received, and other information. The street address for the Docket Office (telephone (800) 647-5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.

List of Subjects in 14 CFR Part 39

Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.