AD 2012-10-09

We are superseding an existing airworthiness directive (AD) for certain Piper Aircraft, Inc. (type certificate previously held by The New Piper Aircraft Inc.) Models PA-31T and PA-31T1 airplanes. That AD currently requires correcting a model identification error on the aircraft data plate. Since we issued that AD, we have become aware that some owner/operators of the affected airplanes modified the aircraft data plate in error because of confusion in the serial number applicability. Because of the confusion, the manufacturer has issued new service information to clarify affected airplane serial numbers. This new AD requires determining the airplane model based on the serial number and modifying the aircraft data plate to properly identify the airplane model. This new AD also requires doing a detailed search for all applicable airworthiness related documents that apply to any airplane that has an incorrectly marked data plate and take necessary corrective actions based on the search findings. We are issuing this AD to correct the unsafe condition on these products.

Final rule.

Adoption of the Amendment

Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0 1. The authority citation for part 39 continues to read as follows:

Authority: 49 U.S.C. 106(g), 40113, 44701.

Sec. 39.13 [Amended]

0 2. The FAA amends Sec. 39.13 by removing airworthiness directive (AD) 80-11-06, amendment 39-3776 (45 FR 35309, May 27, 1980), and adding the following new AD:

[[Page 31171]]

2012-10-09 Piper Aircraft, Inc. (Type Certificate Previously Held by The New Piper Aircraft Inc.): Amendment 39-17058; Docket No. FAA- 2012-0251; Directorate Identifier 2012-CE-002-AD.

(a) Effective Date

This airworthiness directive (AD) is effective June 29, 2012.

(b) Affected ADs

This AD supersedes AD 80-11-06, Amendment 39-3776 (45 FR 35309, May 27, 1980).

(c) Applicability

This AD applies to the airplanes identified in paragraphs (c)(1) and (c)(2) of this AD, certificated in any category.
(1) Model PA-31T airplanes, serial numbers 31T-7820001, 31T- 7820002, 31T-7820003, 31T-7820004, 31T-7820005, 31T-7820006, 31T- 7820007, 31T-7820008, 31T-7820009, 31T-7820010, 31T-7820011, 31T- 7820012, 31T-7820013, 31T-7820014, 31T-7820015, 31T-7820016, 31T- 7820017, 31T-7820018, 31T-7820019, 31T-7820020, 31T-7820021, 31T- 7820022, 31T-7820023, 31T-7820024, 31T-7820025, 31T-7820026, 31T- 7820027, 31T-7820028, 31T-7820029, 31T-7820030, 31T-7820031, 31T- 7820032, 31T-7820033, 31T-7820034, 31T-7820035, 31T-7820036, 31T- 7820037, 31T-7820038, 31T-7820039, 31T-7820040, 31T-7820041, 31T- 7820042, 31T-7820043, 31T-7820044, 31T-7820045, 31T-7820046, 31T- 7820047, 31T-7820048, 31T-7820049, 31T-7820050, 31T-7820051, 31T- 7820052, 31T-7820053, 31T-7820054, 31T-7820055, 31T-7820056, 31T- 7820057, 31T-7820058, 31T-7820059, 31T-7820060, 31T-7820061, 31T- 7820062, 31T-7820063, 31T-7820064, 31T-7820065, 31T-7820066, 31T- 7820067,31T-7820068, 31T-7820069, 31T-7820070, 31T-7820071, 31T- 7820072, 31T-7820073, 31T-7820074, 31T-7820075, 31T-7820076, 31T- 7820077, 31T-7820078, 31T-7820079, 31T-7820080, 31T-7820081, 31T- 7820082, 31T-7820083, 31T-7820084, 31T-7820085, 31T-7820086, 31T- 7820087, 31T-7820088, 31T-7820089, 31T-7820090, 31T-7820091, 31T- 7820092; and
(2) Model PA-31T1 airplanes, serial numbers 31T-7804001, 31T- 7804002, 31T-7804003, 31T-7804004, 31T-7804005, 31T-7804006, 31T- 7804007, 31T-7804008, 31T-7804009, 31T-7804010, 31T-7804011, 31T- 7904001, 31T-7904002, 31T-7904003, 31T-7904004, 31T-7904005, 31T- 7904006, 31T-7904007, 31T-7904008, 31T-7904009, 31T-7904010, 31T- 7904011, 31T-7904012, 31T-7904013, 31T-7904014, 31T-7904015, 31T- 7904016, 31T-7904017, 31T-7904018, 31T-7904019, 31T-7904020, 31T- 7904021, 31T-7904022, 31T-7904023, 31T-7904024, 31T-7904025, 31T- 7904026, 31T-7904027, 31T-7904028, 31T-7904029, 31T-7904030, 31T- 7904031, 31T-7904032, 31T-7904033, 31T-7904034, 31T-7904035, 31T- 7904036, 31T-7904037, 31T-7904038, 31T-7904039, 31T-7904040, 31T- 7904041, 31T-7904042, 31T-7904043, 31T-7904044, 31T-7904045, 31T- 7904046, 31T-7904047, 31T-7904048, 31T-7904049, 31T-7904050, 31T- 7904051, 31T-7904052, 31T-7904053, 31T-7904056, 31T-7904057.

(d) Subject

Joint Aircraft System Component (JASC)/Air Transport Association (ATA) of America Code 1100, Placards and Markings.

(e) Unsafe Condition

This AD was prompted by reports that some owner/operators of the affected airplanes modified the aircraft data plate in error because of confusion in the serial number applicability. We are issuing this AD to correct the unsafe condition on these products.

(f) Compliance

Comply with this AD within the compliance times specified, unless already done.

(g) Inspect the Aircraft Data Plate

Within the next 100 hours after June 29, 2012 (the effective date of this AD), inspect the markings on the aircraft data plate. Do the inspection following Part I of Piper Aircraft, Inc. Mandatory Service Bulletin No. 1235, dated November 3, 2011.
(1) If the aircraft data plate is correctly marked, make a logbook entry showing compliance with this AD, and no further action is required.
(2) If the aircraft data plate is incorrectly marked, continue with paragraphs (h) and (i) of this AD.

(h) Modify the Aircraft Data Plate

Before further flight after the inspection required in paragraph (g) of this AD, modify the aircraft data plate following Part II of Piper Aircraft, Inc. Mandatory Service Bulletin No. 1235, dated November 3, 2011.

(i) Detailed Aircraft Records Search

Before further flight after the modification required in paragraph (h) of this AD:
(1) Do a detailed search of the aircraft maintenance records and documents to include, but not limited to, ADs, special airworthiness information bulletins (SAIBs), service bulletins (SBs), and other service documents; installed supplemental type certificates (STCs) and parts manufacturing approval (PMAs); and instructions for continued airworthiness (ICAs). Each document found must be assessed to ensure proper actions have been made to maintain airworthiness as affected by the model number of the aircraft. Part 135 operators and other operators utilizing FAA-approved maintenance programs will need to address changes to their inspection programs and related documents.

Note 1 to paragraph (i)(1) of this AD: Although some of the above documents may not be mandatory for compliance, it is still necessary to evaluate them to ensure that any voluntary compliance does not negatively affect the airworthiness of the airplane.

(2) Identify all discrepant conditions for misidentified aircraft and coordinate with the geographic Flight Standards District Office (FSDO) and the Atlanta Aircraft Certification Office (ACO) to determine necessary corrective actions. Also, coordinate with the geographic FSDO to arrange for revisions to the airworthiness certificate, registration, and other potential document/certificate revisions. The following is a list of example discrepant conditions that may be found during the records search:
(i) An AD was complied with that was applicable to the incorrect model, but not applicable to the corrected model.
(ii) A required AD for the corrected model was not complied with.
(iii) A maintenance action was performed that was recommended, but not mandatory, for the incorrect model, but not applicable to the corrected model.
(iv) A PMA part was installed that was applicable for the incorrect model, but not for the corrected model.
(v) An STC was installed that was applicable for the incorrect model, but not for the corrected model.
(vi) An STC was installed that was applicable for both the incorrect and corrected model, but all related, applicable ADs for the corrected model were not complied with.

(j) Alternative Methods of Compliance (AMOCs)

(1) The Manager, Atlanta Aircraft Certification Office (ACO), has the authority to approve AMOCs for this AD, if requested using the procedures found in 14 CFR 39.19. In accordance with 14 CFR 39.19, send your request to your principal inspector or local Flight Standards District Office, as appropriate. If sending information directly to the manager of the ACO, send it to the attention of the person identified in the Related Information section of this AD.
(2) Before using any approved AMOC, notify your appropriate principal inspector, or lacking a principal inspector, the manager of the local flight standards district office/certificate holding district office.
(3) AMOCs approved for AD 80-11-06 (45 FR 35309, May 27, 1980), are approved as AMOCs for this AD.

(k) Related Information

For more information about this AD, contact Gregory ``Keith'' Noles, Aerospace Engineer, FAA, Atlanta ACO, 1701 Columbia Avenue, College Park, Georgia 30337; phone: (404) 474-5551; fax: (404) 474- 5606; email: gregory.noles@faa.gov.

(l) Material Incorporated by Reference

(1) You must use Piper Aircraft, Inc. Mandatory Service Bulletin No. 1235, dated November 3, 2011, to do the actions required by this AD, unless the AD specifies otherwise. The Director of the Federal Register approved the incorporation by reference (IBR) under 5 U.S.C. 552(a) and 1 CFR part 51.
(2) For service information identified in this AD, contact Piper Aircraft, Inc., 926 Piper Drive, Vero Beach, Florida 32960; telephone: (772) 567-4361; Internet: www.piper.com.
(3) You may review copies of the service information at the FAA, Small Airplane Directorate, 901 Locust, Kansas City, Missouri 64106. For information on the availability of this material at the FAA, call (816) 329-4148.
(4) You may also review copies of the service information that is incorporated by reference at the National Archives and

[[Page 31172]]

Records Administration (NARA). For information on the availability of this material at NARA, call 202-741-6030, or go to: http://www.archives.gov/federal-register/cfr/ibr_locations.html.

Discussion

We issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to supersede AD 80-11-06, amendment 39-3776 (45 FR 35309, May 27, 1980). That AD applies to the specified products. The NPRM published in the Federal Register on March 9, 2012 (77 FR 14316). The NPRM proposed to retain all requirements of AD 80-11-06, amendment 39- 3776 (45 FR 35309, May 27, 1980) and clarify the serial number applicability of the affected model airplanes. The NPRM also proposed to require a detailed search for all applicable airworthiness related documents that apply to any airplane that has an incorrectly marked aircraft data plate and take necessary corrective actions.

Comments

We gave the public the opportunity to participate in developing this AD. We received no comments on the NPRM (77 FR 14316, March 9, 2012) or on the determination of the cost to the public.

Conclusion

We reviewed the relevant data and determined that air safety and the public interest require adopting the AD as proposed except for minor editorial changes. We have determined that these minor changes:
Are consistent with the intent that was proposed in the NPRM (77 FR 14316, March 9, 2012) for correcting the unsafe condition; and
Do not add any additional burden upon the public than was already proposed in the NPRM (77 FR 14316, March 9, 2012).

Costs of Compliance

We estimate that this AD affects 158 airplanes of U.S. registry.
We estimate the following costs to comply with this AD:

Estimated Costs ----------------------------------------------------------------------------------------------------------------
Cost per Cost on U.S.
Action Labor cost Parts cost product operators ---------------------------------------------------------------------------------------------------------------- Inspect the aircraft data plate... 1 work-hour x $85 per Not applicable....... $85 $13,430
hour = $85. ----------------------------------------------------------------------------------------------------------------

We estimate the following costs to do any necessary modification and/or records search that will be required based on the results of the inspection. We have no way of determining the number of aircraft that might need modification:

On-Condition Costs ----------------------------------------------------------------------------------------------------------------
Cost per
Action Labor cost Parts cost product ---------------------------------------------------------------------------------------------------------------- Modify the aircraft data plate......... 1 work-hour x $85 per hour Not applicable............ $85
= $85. Detailed search for all applicable 4 work-hours x $85 per hour Not applicable............$340
airworthiness related documents that = $340.
apply to any airplane that has an
incorrectly marked aircraft data plate. ----------------------------------------------------------------------------------------------------------------

Authority for This Rulemaking

Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, Section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701, ``General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.

Regulatory Findings

We have determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
(1) Is not a ``significant regulatory action'' under Executive Order 12866,
(2) Is not a ``significant rule'' under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979),
(3) Will not affect intrastate aviation in Alaska, and
(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.

List of Subjects in 14 CFR Part 39

Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.