Discussion
On September 15, 2011, we issued Emergency AD 2011-20-51, which requires the removal of affected PMA replacement TAATI first stage reduction sun gears and the interacting planet gears, from the propeller reduction gearbox assembly. This action was prompted by failures of certain replacement PMA first stage reduction sun gears, manufactured by TAATI. This condition, if not corrected, could result in failure of the shaft portion of the sun gear, which will result in an engine in-flight shut down, possible uncontained engine failure, aircraft damage, and serious injuries.
FAA's Determination
We are issuing this AD because we evaluated all the relevant information and determined the unsafe condition described previously is likely to exist or develop in other products of the same type design.
AD Requirements
This AD requires the removal of affected PMA replacement TAATI first stage reduction sun gear and the interactingplanet gears, from the propeller reduction gearbox assembly, within 15 operating hours or 15 days after the effective date of this AD, whichever occurs first.
FAA's Determination of the Effective Date
An unsafe condition exists that requires the immediate adoption of this AD. The FAA has found that the risk to the flying public justifies waiving notice and comment prior to adoption of this rule because of the short compliance time required in this AD to remove any affected parts from service. Therefore, we find that notice and opportunity for prior public comment are impracticable and that good cause exists for making this amendment effective in less than 30 days.
Comments Invited
This AD is a final rule that involves requirements affecting flight safety and was not preceded by notice and an opportunity for public comment. However, we invite you to send any written data, views, or arguments about this AD. Send your comments to an address listed under the ADDRESSESsection. Include the docket number FAA-2011-1038 and Directorate Identifier 2011-NE-31-AD at the beginning of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of this AD. We will consider all comments received by the closing date and may amend this AD because of those comments.
We will post all comments we receive, without change, to http://www.regulations.gov, including any personal information you provide. We will also post a report summarizing each substantive verbal contact we receive about this AD.
Costs of Compliance
We estimate that the inspection in this AD will affect about 5,000 engines installed on airplanes of U.S. registry. We also estimate that disassembly of reduction gearboxes will affect about 50 engines, and the sun gear removal will affect about 40 engines. We also estimate that it will take about 1 work-hour per engine for inspecting the engine records. We also estimate that for about 10 engines, it will take about 10 work-hours for the inspection of the sun gear serial number (S/N) and reassembly of the reduction gearbox, due to the records not identifying the S/N. We also estimate that it would take about 16 work-hours for parts replacement. The average labor rate is $85 per work-hour. Required parts for one engine will cost about $14,500. Based on these figures, we estimate the cost of the AD on U.S. operators to be $1,067,900.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. Subtitle VII: Aviation Programs describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in subtitle VII, part A, subpart III, section 44701: ``General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraftin air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
This AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
(1) Is not a ``significant regulatory action'' under Executive Order 12866,
(2) Is not a ``significant rule'' under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979),
(3) Will not affect intrastate aviation in Alaska, and
(4) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.
[[Page 64003]]