Discussion
We issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to include an AD that would apply to the specified products. That NPRM was published in the Federal Register on October 28, 2009 (74 FR 55491). That NPRM proposed to correct an unsafe condition for the specified products. The MCAI states:
During acceleration up to OEI 30-second rating, one event of flight loss of full automatic control occurred on an Arriel 2S1 engine.
The selection of OEI 30-second rating on engine 1 was triggered by the automatic detection of an OEI situation further to a transient deceleration of engine 2. The transient deceleration of engine 2 was caused by the untimely reset of its DECU. Once this reset was completed, engine 2 resumed its nominal operation. Afterwards the aircraft then continued its flight safely with its engine 1 operating in manual control mode.
The loss of full automatic control of engine 1 was caused by loss of steps of the stepper motor controlling the fuel metering valve inside the HMU.
It has been found that high accelerations, notably up to OEI 30- second rating, increase the risk of loss of steps of the HMU stepper motor.
Therefore, this event has led to the consideration of the following unsafe condition at aircraft level: In-flight loss of full automatic control of the engine induced by the loss of steps of the stepper motor during acceleration up to OEI 30-second rating, further to an actual OEI situation on the other engine (such as a power loss event).
Comments
We gave the public the opportunity to participate in developing this AD. We considered the comment received.
One commenter, a private citizen, requests that in the applicability paragraph, we change "S-76C+'' to "S-76C'' which is how it is listed in the helicopter type certificate data sheet.
We agree and changed the AD.
Conclusion
We reviewed the available data, including the comment received, anddetermined that air safety and the public interest require adopting the AD with the change described previously. We determined that these changes will not increase the economic burden on any operator or increase the scope of the AD.
Differences Between This AD and the MCAI or Service Information
The MCAI requires performing the DECU software upgrade no later than August 31, 2010. This AD requires performing the DECU software upgrade within 350 operating hours after the effective date of the AD.
Costs of Compliance
Based on the service information, we estimate that this AD will affect about 136 products of U.S. registry. We also estimate that it will take about 3 work-hours per product to comply with this AD. The average labor rate is $80 per work-hour. Required parts will cost about $3,500 per product. Based on these figures, we estimate the cost of the AD on U.S. operators to be $508,640.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. "Subtitle VII: Aviation Programs,'' describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in "Subtitle VII, Part A, Subpart III, Section 44701: General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
We determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify this AD:
1. Is not a "significant regulatory action'' under Executive Order 12866;
2. Is not a "significant rule'' under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and
3. Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a regulatory evaluation of the estimated costs to comply with this AD and placed it in the AD docket.
Examining the AD Docket
You may examine the AD docket on the Internet at http:// www.regulations.gov; or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this AD, the regulatory evaluation, any comments received, and otherinformation. The street address for the Docket Operations office (telephone (800) 647-5527) is provided in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
Adoption of the Amendment
Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
2. The FAA amends Sec. 39.13 by adding the following new AD: