Discussion
We issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to include an AD that would apply to the specified products. That NPRM was published in the Federal Register on November 27, 2007 (72 FR 66087). That NPRM proposed to correct an unsafe condition for the specified products. The MCAI states:
The Type Certificate Holder (TCH) has received several reports of failed Rudder torque tube assemblies. The torque tube assemblies are subject to repetitive inspection in accordance with Airworthiness Directive 2060 PRE 80. The recent failures occurred in service after the inspections required by AD 2060 PRE 80 had been performed. In the event of such failures, loss of directional control through both the Rudder and Nosewheel Steering may occur. The TCH has also received reports of loose rivets attaching the inboard Anchor Assembly to the Starboard Torque Tube.
The MCAI requires the inspection of the rudder torque tube assemblies and hubs for cracking and loose rivets with conditional correction or replacement following De Havilland Support Limited Service Bulletin B121/65, Issue 2, dated August 10, 2005.
Comments
We gave the public the opportunity to participate in developing this AD. We considered the comment received.
Comment Issue: Reference the Correct TC Holder in the AD
Trevor A. Wood requests that the FAA reference De Havilland Support Ltd. (DHSL) in the proposed AD instead of British Aerospace Aircraft Group, Scottish Division. The commenter points out that DHSL is the organization that has published the service information, and he believes that the current type certificate data sheet for the Beagle B.121 series 1, 2, and 3 airplanes incorrectly references the type certificate holder. The commenter points out that the British Aerospace Aircraft Group, Scottish Division, relinquished responsibility for these airplanes in November 2002 when the type certificate was transferred toDHSL.
The FAA does not agree that the NPRM incorrectly referenced British Aerospace Aircraft Group, Scottish Division, as the type certificate holder. We cannot change the type certificate data sheet without approval and request from the State of Design, in this case the United Kingdom Civil Aviation Authority (CAA) and the European Aviation Safety Agency (EASA). However, since issuance of the NPRM, the FAA has received such approval and request. We have revised the type certificate data sheet (A22EU, Revision 4, dated March 20, 2008) to reference the type certificate holder of the Beagle B.121 series 1, 2, and 3 airplanes as De Havilland Support Limited. We have made the appropriate changes in the final rule AD action to reflect this.
Conclusion
We reviewed the available data, including the comment received, and determined that air safety and the public interest require adopting the AD with the changes described previously. We determined that these changes will not increase the economic burden on any operator or increase the scope of the AD.
Differences Between This AD and the MCAI or Service Information
We have reviewed the MCAI and related service information and, in general, agree with their substance. But we might have found it necessary to use different words from those in the MCAI to ensure the AD is clear for U.S. operators and is enforceable. In making these changes, we do not intend to differ substantively from the information provided in the MCAI and related service information.
We might also have required different actions in this AD from those in the MCAI in order to follow FAA policies. Any such differences are highlighted in a NOTE within the AD.
Costs of Compliance
Based on the service information, we estimate that this AD will affect 1 product of U.S. registry. We also estimate that it will take about 1 work-hour per product to comply with basic requirements of this AD. The average labor rate is $80 per work-hour.
Based on these figures, we estimate the cost of this AD to the U.S. operators to be $80, or $80 per product.
In addition, we estimate that any necessary follow-on actions would take about 12 work-hours and require parts costing $10,000 for a cost of $10,960 per product.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, section 106, describes the authority of the FAA Administrator. "Subtitle VII: Aviation Programs," describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in "Subtitle VII, Part A, Subpart III, Section 44701: General requirements." Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
We determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify this AD:
(1) Is not a "significant regulatory action" under Executive Order 12866;
(2) Is not a "significant rule" under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and
(3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a regulatory evaluation of the estimated costs to comply with this AD and placed it in the AD Docket.
Examining the AD Docket
You may examine the AD docket on the Internet at http:// www.regulations.gov; or in person at the Docket Management Facility between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains the NPRM, the regulatory evaluation, any comments received, and other information. The street address for the Docket Office (telephone (800) 647-5527) is in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.
Adoption of the Amendment
Accordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13[Amended]
2. The FAA amends Sec. 39.13 by adding the following new AD: