The FAA proposed to amend 14 CFR part 39 with a proposed AD. The proposed AD applies to PW PW4164, PW4168, and PW4168A. We published the proposed AD in the Federal Register on May 21, 2007 (72 FR 28459). That action proposed to require removing certain LPT stage 4 disks, P/N 51N404, listed by serial number in the proposed AD, at the next piece-part exposure, or within 7,500 CSN, whichever occurs first.
Examining the AD Docket
You may examine the AD docket on the Internet at http://www.regulations.gov ; or in person at the Docket Operations office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD docket contains this AD, the regulatory evaluation, any comments received, and other information. The street address for the Docket Operations office (telephone (800) 647-5527) is provided in the ADDRESSES section. Comments will be available in the AD docket shortly after receipt.
Comments
We provided the public the opportunity to participate in the development of this AD. We have considered the comment received.
Pratt & Whitney proposes that we not write an AD. Pratt & Whitney states that they performed additional testing for low-cycle fatigue (LCF). They state the testing shows the disks with the 1-hour heat treatment are equivalent to the disks treated with a 4-hour heat treatment. We do not agree. The data that PW presents to us doesn't conclusively show the 1-hour heat-treat LCF capability is equivalent to the 4-hour heat-treat disks. We didn't change the AD.
Conclusion
We have carefully reviewed the available data, including the comment received, and determined that air safety and the public interest require adopting the AD as proposed.
Costs of Compliance
We estimate that this AD will affect 11 engines installed on airplanes of U.S. registry. We also estimate that it will take about 250 work-hours per engine to perform the required action, if not done at piece-part exposure, and that the average labor rate is $80 per work-hour. Required parts will cost about $186,288 per engine. Based on these figures, we estimate the total cost of the AD to U.S. operators to be $2,269,168.
Authority for This Rulemaking
Title 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, Section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority.
We are issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701, "General requirements." Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action.
Regulatory Findings
We have determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that this AD:
(1) Is not a "significant regulatory action" under Executive Order 12866;
(2) Is not a "significant rule" under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and
(3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a summary of the costs to comply with this AD and placed it in the AD Docket. You may get a copy of this summary at the address listed under ADDRESSES.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Safety.
Adoption of the Amendment
Accordingly, under the authority delegated to me by the Administrator, the Federal Aviation Administration amends 14 CFR part 39 as follows:
PART 39--AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
Sec. 39.13 [Amended]
2. The FAA amends Sec. 39.13 by adding the following new airworthiness directive: