AD 2007-13-02

The FAA is adopting a new airworthiness directive (AD) for all McDonnell Douglas Model DC-8-62, DC-8-62F, DC-8-63, DC-8-63F, DC-8-72, DC-8-72F, and DC-8-73F airplanes. This AD requires deactivating certain components (the sump heater, scavenge valve, and scavenge pump) of the center wing fuel tank. This AD results from fuel system reviews conducted by the manufacturer. We are issuing this AD to prevent certain conditions related to these components, which could lead to a possible ignition source in the fuel tank and a potential fire or explosion.

Final rule.

2007-13-02 McDonnell Douglas: Amendment 39-15106. Docket No. FAA- 2007-27756; Directorate Identifier 2006-NM-255-AD. \n\nEffective Date \n\n\t(a) This AD becomes effective July 25, 2007. \n\nAffected ADs \n\n\t(b) None. \n\nApplicability \n\n\t(c) This AD applies to all McDonnell Douglas Model DC-8-62, DC- 8-62F, DC-8-63, DC-8-63F, DC-8-72, DC-8-72F, and DC-8-73F airplanes, certificated in any category. \n\nUnsafe Condition \n\n\t(d) This AD results from fuel system reviews conducted by the manufacturer. We are issuing this AD to prevent certain conditions related to the sump heater, scavenge valve, and scavenge pump of the center wing fuel tank, which could lead to a possible ignition source in the fuel tank and a potential fire or explosion. \n\nCompliance \n\n\t(e) You are responsible for having the actions required by this AD performed within the compliance times specified, unless the actions have already been done. \n\nDeactivation \n\n\t(f) Within 24 months after the effective date of this AD, deactivate the sump heater, scavenge valve, and scavenge pump of the center wing fuel tank, in accordance with the Accomplishment Instructions of Boeing Alert Service Bulletin DC8-28A089, dated November 1, 2006. \n\nAlternative Methods of Compliance (AMOCs) \n\n\t(g)(1) The Manager, Los Angeles Aircraft Certification Office, FAA, has the authority to approve AMOCs for this AD, if requested in accordance with the procedures found in 14 CFR 39.19. \n\n\t(2) To request a different method of compliance or a different compliance time for this AD, follow the procedures in 14 CFR 39.19. Before using any approved AMOC on any airplane to which the AMOC applies, notify your appropriate principal inspector (PI) in the FAA Flight Standards District Office (FSDO), or lacking a PI, your local FSDO. \n\nMaterial Incorporated by Reference \n\n\t(h) You must use Boeing Alert Service Bulletin DC8-28A089, dated November 1, 2006, to perform the actions that are required by this AD, unless the AD specifies otherwise. The Director of the Federal Register approved the incorporation by reference of this document in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Contact Boeing Commercial Airplanes, Long Beach Division, 3855 Lakewood Boulevard, Long Beach, California 90846, Attention: Data and Service Management, Dept. C1-L5A (D800-0024), for a copy of this service information. You may review copies at the FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or at the National Archives and Records Administration (NARA). For information on the availability of this material at NARA, call 202-741-6030, or go to: http://www.archives.gov/federal-register/cfr/ibr-locations.html .

Examining the Docket \n\n\tYou may examine the airworthiness directive (AD) docket on the Internet at http://dms.dot.gov or in person at the Docket Management Facility office between 9 a.m. and 5 p.m., Monday through Friday, except Federal holidays. The Docket Management Facility office (telephone (800) 647-5227) is located on the plaza level of the Nassif Building at the street address stated in the ADDRESSES section. \n\nDiscussion \n\n\tThe FAA issued a notice of proposed rulemaking (NPRM) to amend 14 CFR part 39 to include an AD that would apply to all McDonnell Douglas Model DC-8-62, DC-8-62F, DC-8-63, DC-8-63F, DC-8-72, DC-8-72F, and DC- 8-73F airplanes. That NPRM was published in the Federal Register on April 4, 2007 (72 FR 16287). That NPRM proposed to require deactivating certain components (the sump heater, scavenge valve, and scavenge pump) of the center wing fuel tank. \n\nComments \n\n\tWe provided the public the opportunity to participate in the development of this AD. We received no comments on the NPRM or on the determination of the cost to the public. \n\nClarification of Alternative Method of Compliance (AMOC) Paragraph \n\n\tWe have revised this action to clarify the appropriate procedure for notifying the principal inspector before using any approved AMOC on any airplane to which the AMOC applies. \n\nConclusion \n\n\tWe have carefully reviewed the available data and determined that air safety and the public interest require adopting the AD with the change described previously. We have determined that this change will neither increase the economic burden on any operator nor increase the scope of the AD. \n\nCosts of Compliance \n\n\tThere are about 119 airplanes of the affected design in the worldwide fleet. The following table provides the estimated costs for U.S. operators to comply with this AD. \n\n\tEstimated Costs\n\n\nWork hours\nAverage labor rate per hour\nCost per airplane\nNumber of U.S.-registered airplanes\nFleet cost\n6\n$80\n$480\n84\n$40,320\n\nAuthority for This Rulemaking \n\n\n\tTitle 49 of the United States Code specifies the FAA's authority to issue rules on aviation safety. Subtitle I, Section 106, describes the authority of the FAA Administrator. Subtitle VII, Aviation Programs, describes in more detail the scope of the Agency's authority. \n\n\tWe are issuing this rulemaking under the authority described in Subtitle VII, Part A, Subpart III, Section 44701, "General requirements.'' Under that section, Congress charges the FAA with promoting safe flight of civil aircraft in air commerce by prescribing regulations for practices, methods, and procedures the Administrator finds necessary for safety in air commerce. This regulation is within the scope of that authority because it addresses an unsafe condition that is likely to exist or develop on products identified in this rulemaking action. \n\nRegulatory Findings \n\n\tWe have determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national government and the States, or on the distribution of power and responsibilities among the various levels of government. \n\n\tFor the reasons discussed above, I certify that this AD: \n\n\t(1) Is not a "significant regulatory action'' under Executive Order 12866; \n\n\t(2) Is not a "significant rule'' under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and \n\n\t(3) Will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. \n\n\tWe prepared a regulatory evaluation of the estimated costs to comply with this AD and placed it in the AD docket. See the ADDRESSES section for a location to examine the regulatory evaluation. \n\nList of Subjects in 14 CFR Part 39 \n\n\tAir transportation, Aircraft, Aviation safety, Incorporation by reference, Safety. \n\nAdoption of the Amendment \n\nAccordingly, under the authority delegated to me by the Administrator, the FAA amends 14 CFR part 39 as follows: \n\nPART 39--AIRWORTHINESS DIRECTIVES \n\n1. The authority citation for part 39 continues to read as follows: \n\n\tAuthority: 49 U.S.C. 106(g), 40113, 44701. \n\nSec. 39.13 (Amended) \n\n2. The Federal Aviation Administration (FAA) amends Sec. 39.13 by adding the following new airworthiness directive (AD):