Transport Canada, which is the airworthiness authority for Canada, recently notified us that an unsafe condition might exist on PWC PT6B-36A and PT6B-36B turboshaft engines. Transport Canada advises that a compressor rear hub, P/N 3018111, was discovered that exceeded the published life limit. This occurred because the operator used an incorrect life limit calculation. PWC investigated and confirmed that PWC Service Bulletin (SB) No. 11002, Original issue- through-Revision 7, incorrectly listed the Flight Count Factor (FCF) of 1 for compressor rear hubs, P/N 3018111. The correct FCF for that part is 3.
Relevant Service Information
We have reviewed and approved the technical contents of PWC SB No. 11002, Revision 8, dated June 11, 2003, that provides the service life limit and correct FCF for compressor rear hubs P/N 3018111. Transport Canada classified this service bulletin as mandatory and issued AD CF- 2003-16, dated June 27, 2003, to ensure the airworthiness of these PT6B-36A and PT6B-36B turboshaft engines in Canada.
Bilateral Airworthiness Agreement
These PWC PT6B-36A and PT6B-36B turboshaft engines are manufactured in Canada and are type certificated for operation in the United States under the provisions of section 21.29 of the Federal Aviation Regulations (14 CFR 21.29) and the applicable bilateral airworthiness agreement. Under this bilateral airworthiness agreement, Transport Canada kept the FAA informed of the situation described above. We have examined the findings of Transport Canada, reviewed all available information, and determined that AD action is necessary for products of this type design that are certificated for operation in the United States.
FAA's Determination and Requirements of This AD
The unsafe condition described previously is likely to exist or develop on other PWC PT6B-36A and PT6B-36B turboshaft engines of the same type design. We are issuing this AD to prevent uncontained failureof the compressor rear hub and damage to the airplane. This AD requires reviewing, and correcting if necessary the critical part record for compressor rear hubs, P/N 3018111. This AD also requires removing compressor rear hubs from service that exceed the published part life limit, before further flight. You must use the service information described previously to perform the actions required by this AD.
FAA's Determination of the Effective Date
Since an unsafe condition exists that requires the immediate adoption of this AD, we have found that notice and opportunity for public comment before issuing this AD are impracticable, and that good cause exists for making this amendment effective in less than 30 days.
Docket Management System (DMS)
We have implemented new procedures for maintaining AD dockets electronically. As of May 17, 2004, we post new AD actions on the DMS and assign a DMS docket number. We track each action and assign a corresponding Directorate identifier. The DMS docket No. is in the form "Docket No. FAA-200X-XXXXX." Each DMS docket also lists the Directorate identifier ("Old Docket Number") as a cross-reference for searching purposes.
Comments Invited
This AD is a final rule that involves requirements affecting flight safety and was not preceded by notice and an opportunity for public comment; however, we invite you to submit any written relevant data, views, or arguments regarding this AD. Send your comments to an address listed under ADDRESSES. Include "AD Docket No. FAA-2004-19170; Directorate Identifier 2004-NE-18-AD" in the subject line of your comments. We specifically invite comments on the overall regulatory, economic, environmental, and energy aspects of the rule that might suggest a need to modify it.
We will post all comments we receive, without change, to http://dms.dot.gov , including any personal information you provide. We will also post a report summarizing each substantive verbal contact with FAA personnel concerning this AD. Using the search function of the DMS web site, anyone can find and read the comments in any of our dockets, including the name of the individual who sent the comment (or signed the comment on behalf of an association, business, labor union, etc.). You may review the DOT's complete Privacy Act Statement in the Federal Register published on April 11, 2000 (65 FR 19477-78) or you may visit http://dms.dot.gov.
We are reviewing the writing style we currently use in regulatory documents. We are interested in your comments on whether the style of this document is clear, and your suggestions to improve the clarity of our communications with you. You can get more information about plain language at http://www.faa.gov/language and http://www.plainlanguage.gov.
Examining the AD Docket
You may examine the docket that contains the AD, any comments received, and any final disposition in person at the DMS Docket Offices between 9 a.m. and 5 p.m., Monday throughFriday, except Federal holidays. The Docket Office (telephone (800) 647-5227) is located on the plaza level of the Department of Transportation Nassif Building at the street address stated in ADDRESSES. Comments will be available in the AD docket shortly after the DMS receives them.
Regulatory Findings
We have determined that this AD will not have federalism implications under Executive Order 13132. This AD will not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government.
For the reasons discussed above, I certify that the regulation:
1. Is not a "significant regulatory action" under Executive Order 12866;
2. Is not a "significant rule" under the DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and
3. Will not have a significant economic impact, positive or negative, on a substantialnumber of small entities under the criteria of the Regulatory Flexibility Act.
We prepared a summary of the costs to comply with this AD and placed it in the AD Docket. You may get a copy of this summary by sending a request to us at the address listed under ADDRESSES.
List of Subjects in 14 CFR Part 39
Air transportation, Aircraft, Aviation safety, Incorporation by reference, Safety.
Adoption of the Amendment
Under the authority delegated to me by the Administrator, the FAA amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows:
PART 39--AIRWORTHINESS DIRECTIVES
1. The authority citation for part 39 continues to read as follows:
Authority: 49 U.S.C. 106(g), 40113, 44701.
39.13 [Amended]
2. The Federal Aviation Administration (FAA) amends 39.13 by adding the following new airworthiness directive (AD):