AD 2002-23-16

This amendment adopts a new airworthiness directive (AD), applicable to certain McDonnell Douglas Model MD-90-30 airplanes. This action requires replacement of the Captain's and First Officer's chart holder assemblies on the cockpit control columns with new, improved assemblies. This action is necessary to prevent interference between the cockpit control wheels and the chart holder assembly, which could result in restricted movement of the control wheel travel when rotating the right- and left-wing-down, and consequent reduced controllability of the airplane. This action is intended to address the identified unsafe condition.

Final rule; request for comments.

2002-23-16 McDonnell Douglas: Amendment 39-12960. Docket 2001-NM- 375-AD. \n\n\tApplicability: Model MD-90-30 airplanes, as listed in Boeing Alert Service Bulletin MD90-25A070, Revision 01, dated February 26, 2002; certificated in any category. \n\n\tNote 1: This AD applies to each airplane identified in the preceding applicability provision, regardless of whether it has been modified, altered, or repaired in the area subject to the requirements of this AD. For airplanes that have been modified, altered, or repaired so that the performance of the requirements of this AD is affected, the owner/operator must request approval for an alternative method of compliance in accordance with paragraph (c) of this AD. The request should include an assessment of the effect of the modification, alteration, or repair on the unsafe condition addressed by this AD; and, if the unsafe condition has not been eliminated, the request should include specific proposed actions to address it. \n\n\tCompliance: Required as indicated, unless accomplished previously. \n\n\tTo prevent interference between the cockpit control wheels and the chart holder assembly, which could result in restricted movement of the control wheel travel when rotating the right- and left-wing- down, and consequent reduced controllability of the airplane, accomplish the following: \n\nReplacement \n\n\t(a) Within 18 months after the effective date of this AD: Replace the Captain's and First Officer's chart holder assemblies on the cockpit control columns with new assemblies (including a functional test after replacement), per Boeing Alert Service Bulletin MD90-25A070, excluding Evaluation Form, Revision 01, dated February 26, 2002. \n\nReplacement Accomplished Per Previous Issue of Service Bulletin \n\n\t(b) Accomplishment of the replacement before the effective date of this AD per Boeing Alert Service Bulletin MD90-25A070, dated November 8, 2001, is considered acceptable for compliance with paragraph (a) of this AD. \n\nAlternative Methods of Compliance \n\n\t(c) An alternative method of compliance or adjustment of the compliance time that provides an acceptable level of safety may be used if approved by the Manager, Los Angeles Aircraft Certification Office (ACO), FAA. Operators shall submit their requests through an appropriate FAA Principal Maintenance Inspector, who may add comments and then send it to the Manager, Los Angeles ACO. \n\n\tNote 2: Information concerning the existence of approved alternative methods of compliance with this AD, if any, may be obtained from the Los Angeles ACO. \n\nSpecial Flight Permits \n\n\t(d) Special flight permits may be issued in accordance with sections 21.197 and 21.199 of the Federal Aviation Regulations (14 CFR 21.197 and 21.199) to operate the airplane to a location where the requirements of this AD can be accomplished. \n\nIncorporation by Reference \n\n\t(e) The actions shall be done per Boeing Alert Service Bulletin MD90-25A070, excluding Evaluation Form, Revision 01, dated February 26, 2002. This incorporation by reference was approved by the Director of the Federal Register in accordance with 5 U.S.C. 552(a) and 1 CFR part 51. Copies may be obtained from Boeing Commercial Aircraft Group, Long Beach Division, 3855 Lakewood Boulevard, Long Beach, California 90846, Attention: Data and Service Management, Dept. C1-L5A (D800-0024). Copies may be inspected at the FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, Washington; or at the FAA, Los Angeles Aircraft Certification Office, 3960 Paramount Boulevard, Lakewood, California; or at the Office of the Federal Register, 800 North Capitol Street, NW., Suite 700, Washington, DC. \n\nEffective Date \n\n\t(f) This amendment becomes effective on December 11, 2002.

The FAA has received information from an MD- 90 flight simulator manufacturer of an interference problem between the cockpit control wheels and the Captain's and First Officer's chart holder assemblies on the cockpit control columns. Investigation revealed that when the control wheels are rotated both right-wing-down and left-wing-down, the grips/horns strike the left and right edge of the existing chart holders. Such interference restricts movement to a maximum of 107 to 109 degrees. The roll control tab stops are set at 116 degrees (no air load), and the travel-to-wheel stops are identified as 135 degrees. Such interference, if not corrected, could result in restricted movement of the control wheel travel when rotating the right- and left-wing-down, and consequent reduced controllability of the airplane. \n\nExplanation of Relevant Service Information \n\n\tWe have reviewed and approved Boeing Alert Service Bulletin MD90- 25A070, excluding Evaluation Form, Revision 01, dated February 26, 2002, which describes procedures for replacement of the Captain's and First Officer's chart holder assemblies located on the cockpit control columns, with new, improved assemblies. The service bulletin also references the airplane maintenance manual which describes procedures for a functional test after doing the replacement. Accomplishment of the actions specified in the service bulletin is intended to adequately address the identified unsafe condition. \n\nExplanation of Requirements of the Rule \n\n\tSince an unsafe condition has been identified that is likely to exist or develop on other airplanes of the same type design that may be registered in the United States at some time in the future, the actions are required to be accomplished in accordance with the service bulletin described previously, except that the AD does not require completing the Evaluation Form. \n\nCost Impact \n\n\tNone of the Model MD-90-30 airplanes affected by this action are on the U.S. Register. All airplanes included in the applicability of this rule currently are operated by non-U.S. operators under foreign registry; therefore, they are not directly affected by this AD action. However, the FAA considers that this rule is necessary to ensure that the unsafe condition is addressed in the event that any of these subject airplanes are imported and placed on the U.S. Register in the future. \n\n\tShould an affected airplane be imported and placed on the U.S. Register in the future, it would require approximately 1 work hour to accomplish the required replacement, at an average labor rate of $60 per work hour. Parts will be provided by the manufacturer at no cost to operators. Based on these figures, the cost impact of the replacement required by this AD would be $60 per airplane. \n\nDetermination of Rule's Effective Date \n\n\tSince this AD action does not affect any airplane that is currently on the U.S. register, it has no adverse economic impact and imposes noadditional burden on any person. Therefore, prior notice and public procedures hereon are unnecessary and the amendment may be made effective in less than 30 days after publication in the Federal Register. \n\nComments Invited \n\n\tAlthough this action is in the form of a final rule and was not preceded by notice and opportunity for public comment, comments are invited on this rule. Interested persons are invited to comment on this rule by submitting such written data, views, or arguments as they may desire. Communications shall identify the Rules Docket number and be submitted in triplicate to the address specified under the caption ADDRESSES. All communications received on or before the closing date for comments will be considered, and this rule may be amended in light of the comments received. Factual information that supports the commenter's ideas and suggestions is extremely helpful in evaluating the effectiveness of the AD action and determining whether additional rulemaking action would be needed. \n\n\tSubmit comments using the following format: \n\nOrganize comments issue-by-issue. For example, discuss a request to change the compliance time and a request to change the service bulletin reference as two separate issues. \n\nFor each issue, state what specific change to the AD is being requested. \n\nInclude justification (e.g., reasons or data) for each request. \n\n\tComments are specifically invited on the overall regulatory, economic, environmental, and energy aspects of the rule that might suggest a need to modify the rule. All comments submitted will be available, both before and after the closing date for comments, in the Rules Docket for examination by interested persons. A report that summarizes each FAA-public contact concerned with the substance of this AD will be filed in the Rules Docket. \n\n\tCommenters wishing the FAA to acknowledge receipt of their comments submitted in response to this rule must submit a self-addressed, stamped postcard on which the following statement is made: "Comments to Docket Number 2001-NM-375-AD." The postcard will be date stamped and returned to the commenter. \n\nRegulatory Impact \n\n\tThe regulations adopted herein will not have a substantial direct effect on the States, on the relationship between the national Government and the States, or on the distribution of power and responsibilities among the various levels of government. Therefore, it is determined that this final rule does not have federalism implications under Executive Order 13132. \n\n\tFor the reasons discussed above, I certify that this action (1) is not a "significant regulatory action" under Executive Order 12866; (2) is not a "significant rule" under DOT Regulatory Policies and Procedures (44 FR 11034, February 26, 1979); and (3) will not have a significant economic impact, positive or negative, on a substantial number of small entities under the criteria of the Regulatory Flexibility Act. A final evaluation has been prepared for this action and it is contained in the Rules Docket. A copy of it may be obtained from the Rules Docket at the location provided under the caption ADDRESSES. \n\nList of Subjects in 14 CFR Part 39 \n\n\tAir transportation, Aircraft, Aviation safety, Incorporation by reference, Safety. \n\nAdoption of the Amendment \n\n\tAccordingly, pursuant to the authority delegated to me by the Administrator, the Federal Aviation Administration amends part 39 of the Federal Aviation Regulations (14 CFR part 39) as follows: \n\nPART 39--AIRWORTHINESS DIRECTIVES \n\n\t1. The authority citation for part 39 continues to read as follows: \n\n\tAuthority: 49 U.S.C. 106(g), 40113, 44701. \n\n§ 39.13 (Amended) \n\n\t2. Section 39.13 is amended by adding the following new airworthiness directive: